Airbag bursts when vessel's stern dropped down caused by low water level

Water level
Although airbags can overcome water deficiency to a certain extent, they are still have limitations of water levels. If vessels carry out their launch at deficient water, following phenomena may happen: The stern drops abruptly - that may cause brust of marine airbags and fractures of launch ramps. Sometime, it may also cause the raise of bow which may lead to the collision between the bow and the ground.

To avoid above phenomena, following ways can be tried to solve the problems:

• Extend slipway of underwater part.
• Increase ship buoyancy by means of adding buoyancy tanks or airbags to vessels' cabins.

Ship launching failure is caused by rugged launching ramp

Launch ramp
Ship launching accident happens every year all over the world, whatever the launching method is. Although ship launching with airbags is considered to be the most safety launching method, but there are still failures owing to improper operation. In that situation, people always blame the quality of airbags, but they ignore the importance of launching ramps.

Launch ramp also should be prepared, may not be a concrete ramp, but a clean and compacted ramp. In the left picture, the ramp are full of stones and rubbish, which make the ramp too rugged to roll. Inferior ramp also may damage the airbags and the hull of vessels.

Ship holding system also can effect the result of ship launching

Holding system
Ignorance of ship holding system such as ground anchor, pulley, wire ropes, winch and shackles may cause a ship launching accident. For example, bulldozers that used to hold the ship are launched into water undoubtedly as they can not provide enough holding strength.
Tip:

• Excellent arrangements and precise calculation should be made to avoid above accidents.
• Holding system should be checked before launching.